空壓機氣源系列

◆產品特點 Product features

1. 電機是特質的低轉速壓縮機用電機，SKF軸承，絕緣等級F級，防護等級IP54，確保無故障運行。效率較同類產品高3-5%。

2. 油過濾器采用航空用高端材料過濾的旋裝式油過濾器，效果比常規濾芯高20%,有效延長主機正常使用壽命。

3. 超大容量的油氣分離器，品質優越的油氣分離元件和氣、液過濾元件，配以三次油氣分離，含油量控制在3ppm以下，保證壓縮空氣的高質量。

4. 采用具有較好的容塵能力和較低的流動阻力設計，可濾除空氣中的微小固體顆粒，除塵效果達99.5%，確保系統的各個零部件的功能正常運行和經濟的使用壽命。

5. 設計進氣閥，近期調整范圍0-100%，容調閥調節，壓力損失小，動作穩定，壽命長。

6. 螺桿機、效率、低轉速，轉子采用第三代5：6齒形，型線設計，低噪音、低耗能、低維護費用，可靠性和使用壽命。

1. Motor is characteristic of low rotation speed compressor motor, SKF bearing, special insulation is Level F, pretection class is IP54, ensure trouble-free operation. Efficiency is similar products high 3 to 5%.

2. Oil filter used in high-end materials of filter air spin loading oil filter, the effect is 20 percent higher  than conventional filter, prolong the host normal life.

3. Large capacity of the oil and gas separator, superior quality of oil and gas separation components and gas, liquid filtration components, match with advanced design of three oil and gas separation, oil content in 3 PPM, it can keep the compressed air in a high quality.

4. Design it in a higher let dust capacity and low rolling resistance, it can filter out the tiny air solid particles, dust cleaning effect of 99.5%, ensure that all parts of the system function can work well and economic service life.

5. Design is advanced into the valve, the recent adjusting range is 0 to 100%, let the valve adjust, low pressure drop, steady movement, long service life.

6. The world's top screw machine, high efficiency and low speed, rotor covered by use of the third class 5:6 generation of tooth shape, the world's bes ttype line design, low noise, low consumption, low maintenance costs, the best reliability and life.

◆主要技術參數 Main technical parameters

螺桿式空氣壓縮機

◆ 主要技術參數 Main technical parameters

冷凍式空氣干燥機

◆ 工作原理 Working principle

冷干機是根據冷凍除濕原理，利用全封閉壓縮式制冷系統，對經空壓機排出的壓縮氣體冷卻降溫，使其中所含的大量飽和水蒸氣、油霧凝結液滴，經過經汽水分離后由自動排水器排出，在較高溫度的飽和壓縮氣體進入冷干機的預冷器，在預冷器中與來自蒸發器的干冷氣體進行熱交換，降低溫度后進入制冷系統的蒸發器，與冷媒汽進行第二次熱交換，使本身溫度降到接近于冷媒的蒸發溫度，在兩次降溫過程中，壓縮氣體中的水蒸汽得以凝結成液態水滴并隨氣流進入氣水分離器，分離下來的液態水經自動排水器排出機外，溫度較低的干燥壓縮氣體進入預冷器，與剛進入的濕飽和氣體進行熱交換，使本身溫度得到提高，從而在冷干機排氣口得到含水量較低（即露點較低）、相對濕度也很低的干燥壓縮氣體。冷凍式干燥機由于工作可靠、管理方便、運行費用低廉而成為各行業空壓站房凈化設備的常選機型。

Blotting etc.is is according to the principle of frozen dehumidifier, fully compressed type refrigeration system of air compressor, the discharge of compressed gas cooling cooling, that its contain of lots of saturated steam, oil mist condensation, after the separation of droplets by automatic drainage device after discharge, in high temperature of saturated compressed gas into a type of the blotting etc.is generators, in the condenser and evaporator in from dry gas heat, reduce the temperature of cooling system into the evaporator, and cold media steam on the second heat exchange, make itself the temperature dropped to close to the evaporation temperature, cold media in two cooling process, the steam compressed gas to condense into liquid water drops and with the air into the gas water separator, separation of liquid water down by the automatic drainage device turned out, low temperature drying compressed gas into the tanks, and just got into the wet saturated gas, heat to improve, and temperature itself in blotting etc.is vent get low water content (i.e. a low dew point), relative humidity is also very low dry compressed gas. Freezing drying machine because reliable work, management, and operation cost is low and convenient air compressor station building industry become the first choice of purification equipment model.